Dd15 turbo actuator symptoms

Turbocharger Wastegate Actuator with Heat Shield Fits for Detroit Diesel DD13 DD15 Replaces A4710964399 A4710963599 A4710964999 A4710966099 A4710967499 5.0 out of 5 stars 4 $87.99 $ 87 . 99

0:00 / 11:11 Freightliner Cascadia DD13 DD15 DD16 no power turbo control problem spn 641 fmi 5 no turbo pressure Francisco Amaya 88.1K subscribers Subscribe …The VGT uses an actuator to control the position of a set of vanes within the turbo. These vanes can be adjusted to optimize the flow of exhaust gases through the turbo, and therefore the amount of boost that is produced. On a Cummins ISX engine, the VGT and actuator are located on the exhaust side of the engine. WARNING!!: ⚠️⚠️⚠️Always use the proper tools and safety equipment to perform this job. Failure to perform the job correctly can result in personal injury or ...Have someone turn on key with some air in system and watch turbo actuator, it should cycle up and then down. throw some soapy water on actuator with engine running at high idle (1000 RPM or better)..sounds like actuator is leaking...also check wires at plug to VPOD that controls turbo. ... Freightliner Cascadia DD15 2018... emilko posted Oct 16 ...the wastegate actuator move? a. Yes; Go to step 39. b. No; Go to step 22. 22. Drain the vehicle air tanks until the air pressure is 0 bar (0 psi). ... For DD15 (non-AT) and DD16: Refer to section "Removal of the DD15 and the DD16 Turbocharger". Verify repair. For DD15 AT: Refer to section "Removal of the GHG14 DD15 Asymmetrical Turbocharger ...can cause J1939 fault codes while a health report is generated. Updated DTC list in "Symptoms". 12/09/2015 ‐ Added 2010+ V8 specific information for TMV, edited coding. Changed applies to and added a note regarding applicable models. ŁThis article is for general J1939 troubleshooting on 250k baud data link vehicles.

SPN 157 - FMI 16 (Fault Code 553) Blog.Teknisi Tuesday, December 22, 2015 Fault Codes CUMMINS ISB ISC ISL ISBe ISDe and QSB3.3 CM2150. SPN157 FMI16 (Injector Metering Rail Number 1 Pressure - Data Valid but Above Normal Operating Range) Fault Code: 553. ISB with CM2150 - Fuel Rail Pressure Sensor. CODES: Fault Code: …Description. Used Detroit DD15 Turbo Acutator for sale. DETROIT DD15 egr valve actuator P/N# A470150694. Item SKU: 24757082. Price: $290.00.Detroit DD15 #3768075 Turbo Without Actuator ($400 Refundable Core) $ 1,400.00. 60 in stock. Add to cart. Add to Wishlist. Compare. SKU: 3768075 DETROIT DD15 Categories: Detroit Turbos, Diesel Turbos, Shop. Description.EGR Actuator (DD13 & DD15) Red / Black: DKI470E16022-41: A0001506136: Refer to section "Removal of the DD13 and DD15 Exhaust Gas Recirculation Valve Actuator" of the Workshop Manual: EGR Actuator (DD16) Red / Black: DKI470E16022-41: A0001506436: Refer to section "Removal of the DD16 Exhaust Gas Recirculation Valve Actuator" of the Workshop ManualEngine Make. Detroit. Engine Model. DD15. DD15 Throttle Actuator, Part # A4600980210, Replaces A4600980310. All Used Engine Parts Sold... 1-877-781-7766. Email Seller. Text Seller More Details.The AHI module’s purpose is to regulate and control the amount of fuel that goes to the 7th injector during the DPF regeneration process. The AHI module goes through various self-checks during the operation of the engine. If the system detects an issue, it will automatically cause an active fault code related to the AHI module or 7th injector.The turbo actuator does a simple but vital job – it acts as a pressure relief valve that controls the boost output of your turbo, diverting excess exhaust gases away from the turbine wheel. This controls the speed of the turbine, preventing it from over-speeding, and regulating the speed of the compressor. Ultimately, this helps to protect ...

EPA07/10 DD PLATFORM WORKSHOP MANUAL - ENGINE. 20. Using Rocker Arm Lifter / Spacer Intake (W470589044000) (1) for the DD13 or Rocker Arm Lifter / Spacer Intake (W470589004000) for the DD15, install the intake rocker shaft assembly to the camshaft cap and secure with seven clamping blocks and bolts. 21.Below, you will learn more about the most common symptoms associated with turbo failure. 1. Bad Acceleration. A turbo is going to make your vehicle more powerful. With a turbo, your vehicle will accelerate quicker. It is responsible for making your vehicle go from 0 to 60 in a shorter period.Refer to section "Installation and Adjustment of the GHG14 DD13 Turbocharger Wastegate Actuator" b. No; replace the turbocharger. Refer to section "Installation of the DD13 Turbocharger". Verify repair. 42. Remove the clean air intake pipe from the turbocharger. 43. Inspect the turbocharger for damage. Is the turbocharger damaged? a. Yes ...Low fuel level and contaminated fuel clogging up the fuel filter are two main reasons behind the fuel pump failing in your vehicle. No matter how durable or powerful the DD15 engine may be, your vehicle should never run out of fuel. With low fuel level, it prevents your vehicle from functioning as it should and puts an unnecessary amount of ...

Avionics online courses.

Engine rpms stays at the right level but my concern is turbo rpms, intake boost and and that engine brake sound. Replaced engine air filter. Replaced egr delta P. Replaced intake manifold temp. sensor. Replaced egr/turbo actuator . Egr valve position at regen is good its 85-95%. Checked for boost leaks and exhaust leaks. Tried to do couple of ...item 2 For Detroit Turbo Wastegate Actuator DD13 DD15 Turbo Freightliner For Detroit Turbo Wastegate Actuator DD13 DD15 Turbo Freightliner. AU $81.74 +AU $235.71 postage. You may also like. Current slide {CURRENT_SLIDE} of {TOTAL_SLIDES}- You may also like. Car & Truck EGR Valves.A failed Turbo Actuator or VGT Turbo share similar symptoms. Rob from HHP Technical Sales is here to share what key indicators to look for when diagnosing a bad turbo actuator. Talk …Refer to section "Installation of the GHG14 DD15 Asymmetrical Turbocharger Exhaust Gas Recirculation Valve Actuator Pull Rod". 9. Install the turbocharger gasket, and the turbocharger. Refer to section "Installation of the GHG14 DD15 Asymmetrical Turbocharger". 10. Install the EGR/Hot Pipe and turbocharger heat shields. WARNING: PERSONAL INJURYAnother video just showing you how to check for your turbo or actuator being bad. Very common for both of them to be stuck, but sometimes its just one thing ...

Have someone turn on key with some air in system and watch turbo actuator, it should cycle up and then down. throw some soapy water on actuator with engine running at high idle (1000 RPM or better)..sounds like actuator is leaking...also check wires at plug to VPOD that controls turbo. ... Freightliner Cascadia DD15 2018... emilko posted Oct 16 ...Any item may be returned within 14 days as long as it is in new condition and in the original packaging. A restocking fee equal to 10% – 30% of the purchase price will be applied, and any shipping costs may be deducted from the refund. A4720961269 NEW DAP Detroit DD15 Turbo Wastegate Actuator Condition: New Warranty: Twelve (12) months.Table 1 DD15/16 EGR Actuator Replacement Service Kit (P/N: EA4701500794) Removal of the DD15 Exhaust Gas Recirculation Valve Actuator . Remove as follows: 1. Shut off the …For DD15 and DD16: Refer to section "Inspection of the DD15 and DD16 Turbocharger". Is any damage present? a. Yes; in the Test-E worksheet, record an X in the "replace" column for the turbocharger. For DD13 and DD15AT engine, Go to step 6. For DD15TC and DD16 engines, Go to step 5. b. No; for DD13 and DD15AT engines, Go to step 6.Whining noises. Sometimes, you can hear when a turbo is failing – listen out for a distinctive noise when your turbo kicks in at around 1000-1500 rpm. Typically this sounds like a dentists drill, or like a siren, and is a sign that your compressor wheel might be damaged. Any changes in the sound your engine makes when in use are a cause for ...The following are some common turbo problems and failures: – Cracked housings and/or worn seals allow air to escape and cause the turbocharger to work harder and wear down quicker. – A buildup of carbon deposits and contaminants traveling through the system can damage inner engine components. – The presence of foreign objects, such as ...Upgrade Turbo Wastegate Actuator For Cascadia Detroit DD15 DD13 A4720961269. $49.99. Free shipping. Check the item description to confirm this fits your vehicle. Hover to zoom.Dec 26, 2019 · A failed Turbo Actuator or VGT Turbo share similar symptoms. Rob from HHP Technical Sales is here to share what key indicators to look for when diagnosing a bad turbo actuator. Talk to... Here is a more detailed list of the signs of a bad or clogged diesel particulate filter (DPF) to look for: 1. Check Engine Light. The first, and most common sign of a bad DPF is a check engine light on your dashboard. The diesel particulate filter uses sensors to measure the pressure and temperature before and after the DPF filter.Dec 26, 2019 · A failed Turbo Actuator or VGT Turbo share similar symptoms. Rob from HHP Technical Sales is here to share what key indicators to look for when diagnosing a bad turbo actuator. Talk to...

19. Remove the turbocharger heat shield. 20. Remove the hot pipe from the EGR cooler and EGR valve and discard the spherical clamps. Refer to section "Removal of the Exhaust Gas Recirculation Hot Pipe". 21. Disconnect the EGR valve actuator to the actuator pull rod from the EGR valve actuator. Refer to section "Removal of

Mar 6, 2021 · The U010C still pops up after a few key cycles. Of course the dealer wants $6500 for a turbo/actuator replacement. The turbo was not locked up, and the sector gear moved freely when i replaced the actuator. City Diesel has been as helpful as they can be over the phone and email. 5. Install the coolant line to the EGR valve actuator and the banjo bolt on cylinder block. Tighten coolant line to EGR valve actuator and the coolant line banjo bolt into the cylinder block to 35 N·m (26 lb·ft). 6. Connect the EGR valve actuator to the engine wiring harness and attach the EGR valve actuator wiring to the points shown below ...In this video I share my knowledge about the turbo wastegate actuator. If the wastegate actuator is bad, it can cause severe damage to the engine.Wastegate a...Does the EGR actuator move when the ignition is first turned on? a. Yes; Go to step 7. b. No; replace the EGR actuator. Refer to the following section: For DD13, Refer to section "Removal of the DD13 Exhaust Gas Recirculation Valve Actuator". For DD15TC or DD16 equipped with Delphi actuators, Refer to section "Removal of the DD15 and DD16The truck idles fine. Sounds like a jet engine. The actuator does not move up or down on idle. Its steady. When you start the motor and there is no air in the system. When air builds up the rod goes up and the fan switches off. I was thinking maybe my actuator is leaking. But it would show on idle as well.Freightliner Cascadia DD15 turbocharger failure wastegate solenoid air leak low power regen problem Francisco Amaya 88.6K subscribers 19K views 1 year ago …Fit Engine: DD15 Applications: Freightliner Cascadia Horsepower: 455-560HP Model: 14.8L, B3G Reference Part Numbers: A4720901480, RA4720901480, A4710962301 etc. No core charge, Brand new, 1 Year Warranty. Note * This is a direct bolt on aftermarket turbo. * You will get same performance as the original factory turbo with much better price.DD13 and GHG14 asymmetrical turbo DD15 turbocharger wastegate solenoids are being replaced unnecessarily due to air leaks. REQUIRED ACTION The vehicle may have the following complaints: Check Engine Light (2631/1 Low Air Flow, or 3711/31 Parked Regen Failed – DOC In Temp Preventing Dosing) Leaking Air System

Michael bauer.

Big twelve softball tournament.

Find 56 Turbo Actuators by HOLSET, Cummins, Paccar, International, and more on MyLittleSalesman.com. Saved (0) My Account. Sign in Sign up. Control Center. Dashboard. ... (USED) Detroit DD15 TURBO ACTUATOR DD15 APPLICATIONS. Condition: Used: Fits To Make(s) Freightliner: Fits To Model(s) Cascadia: Stock Number: …For DD15 and DD16: Refer to section "Inspection of the DD15 and DD16 Turbocharger". Is any damage present? a. Yes; in the Test-E worksheet, record an X in the "replace" column for the turbocharger. For DD13 and DD15AT engine, Go to step 6. For DD15TC and DD16 engines, Go to step 5. b. No; for DD13 and DD15AT engines, Go to step 6.CASTING #: 3772934. ACTUATOR: NA. VIN #: 3HSCTAPR39N122152. OEM #: 4720962099. USED DETROIT DD15 TURBOCHARGER TAG #2131420. Create Estimate. Part Info. (877)557-8782 Request Info Enterprise LKQ Acme Truck Parts Stockton CA. $1,200.00 ADD TO CART.REPLACE YOUR ISX TURBO ACTUATOR TODAY!!!Click Here= https://tinyurl.com/4m9ymxmbIs your truck showing signs of low boost? Lag? Are my turbo vanes sticking? ...That's why removing the actuator is a good place to start. If you've got a turbo that moves normally, then it's probably an issue with the actuator, if not, you're likely going to want to replace the turbo, and possibly the actuator as well. Other VGT Turbo Problems. If it is your turbo that has failed, you're going to want to figure out what's ...Title: Scanned DocumentRefer to section "Installation and Adjustment of the GHG14 DD13 Turbocharger Wastegate Actuator" b. No; replace the turbocharger. Refer to section "Installation of the DD13 Turbocharger". Verify repair. 42. Remove the clean air intake pipe from the turbocharger. 43. Inspect the turbocharger for damage. Is the turbocharger damaged? a. Yes ... DT12 trans/clutch relearn procedure... 3 Chaz Trimble 1,360 posts since Feb 2, 2015 Re: DT12 trans/clutch relearn procedure fails Jul 10, 2020 4:04 AM ….

There are a few signs that you’re experiencing electronic actuator failure. 1. Your vehicle has a complete loss of power. 2. The engine warning light, or other warning lights, are on. 3. You have low- or over-boost, meaning either your vehicle is lagging or overcompensating when you accelerate. 4. There … See moreAdjustment of the GHG14 DD13 Turbocharger Wastegate Actuator Assembly of Cylinder Head Assembly of the Piston and Connecting Rod Assembly Camshaft Timing Verification Checking and Adjusting Gear Lash with Camshaft Housing Removed ... Description and Operation of the DD15 - DD16 Turbocharger and Related …Tamerx has a great selection of Detroit DD15 Turbo Actuators. Our Online Store makes your purchase experience smooth and enjoyable. Our Inventory is: In Stock and Available, Fast Delivery Options, Made in the USA.Detroit DD15 #3768075 Turbo Without Actuator ($400 Refundable Core) $ 1,400.00. 60 in stock. Add to cart. Add to Wishlist. Compare. SKU: 3768075 DETROIT DD15 Categories: Detroit Turbos, Diesel Turbos, Shop. Description.Joined: Apr 2011. 3 07-29-2012, 03:18 AM. (06-22-2012, 06:18 AM)mega357 Wrote: You need a special calibrated ECM. Sorry for my English. As said, need test ECM is option one, option two is to reprogram current ECM with test ECM serial number, but requires server access. Reply.19. Remove the turbocharger heat shield. 20. Remove the hot pipe from the EGR cooler and EGR valve and discard the spherical clamps. Refer to section "Removal of the Exhaust Gas Recirculation Hot Pipe". 21. Disconnect the EGR valve actuator to the actuator pull rod from the EGR valve actuator. Refer to section "Removal ofLow fuel level and contaminated fuel clogging up the fuel filter are two main reasons behind the fuel pump failing in your vehicle. No matter how durable or powerful the DD15 engine may be, your vehicle should never run out of fuel. With low fuel level, it prevents your vehicle from functioning as it should and puts an unnecessary amount of ...REPLACE YOUR ISX TURBO ACTUATOR TODAY!!!Click Here= https://tinyurl.com/4m9ymxmbIs your truck showing signs of low boost? Lag? Are my turbo vanes sticking? ...a. Yes; replace turbocharger. Refer to section "Removal of the DD13 Turbocharger". Refer to section "Removal of the DD15 and the DD16 Turbocharger". b. No; replace the MCM. Refer to section "Removal of the Motor Control Module".” It seems that replacing the MCM is the last ditch effort to resolve this problem and be able to clear this code. Dd15 turbo actuator symptoms, Diagnosis of a Bad Turbo Actuator, VGT Turbocharger Problems and FailureShop New Turbo Actuators at Highway and Heavy Parts! https://highwayandheavyparts.c..., Description. Used Detroit DD15 Turbo Acutator, P/N 28121241 for sale, from a 2011 Freightliner cascadia Truck. DD15 turbo actuator. Item SKU: 25420477. Price: $636.00., Duramax Diesel. VGT SOLENOID. fits. GM / Chevy / GMC. 2004.5 - 2016 Duramax (LLY, LBZ, LMM, and LML) 2004 - 2009 Topkick and Kodiak 4500 - 8500 (6.6L and 7.8L) Note to 2004 owners only: This Duramax VGT solenoid actuator will only fit late 2004 models equipped with the LLY engine. To ensure that you have the LLY engine, please verify …, to the turbocharger because defects in other components can produce the same symptoms. The turbocharger performance can only be impaired by mechanical damage or blockage caused by dirt. This checklist provides a comprehensive list of the most common symptoms related to turbocharger failure. BEFORE replacing a turbocharger, verify …, A loud whining noise is among the first sign of a DD15 fuel pump issue. When operating, an old or damaged fuel pump may make an audible whine or scream. During routine functioning, most fuel pumps may emit a low hum; however, a loud whine emanating from your vehicle's fuel tank is typically a symptom of trouble., Command the PWM 10 to 70%; wastegate actuator rod should begin to move.[c] Command the PWM 10 to 90%; wastegate actuator rod should be fully open. Go to next step. [d] If the actuator fails to move, verify air supply pressure equals truck air pressure. If pressure is OK, replace the VPOD. 16. Check the brakegate actuator., DT12 trans/clutch relearn procedure... 3 Chaz Trimble 1,360 posts since Feb 2, 2015 Re: DT12 trans/clutch relearn procedure fails Jul 10, 2020 4:04 AM, Detroit DD15 #3768075 Turbo Without Actuator ($400 Refundable Core) $ 1,400.00. 60 in stock. Add to cart. Add to Wishlist. Compare. SKU: 3768075 DETROIT DD15 Categories: Detroit Turbos, Diesel Turbos, Shop. Description., Amazon.com: Turbocharger Wastegate Actuator with Heat Shield Fits for Detroit Diesel DD13 DD15 Replaces A4710964399 A4710963599 A4710964999 …, DD13 and GHG14 asymmetrical turbo DD15 turbocharger wastegate solenoids are being replaced unnecessarily due to air leaks. REQUIRED ACTION The vehicle may have the following complaints: Check Engine Light (2631/1 Low Air Flow, or 3711/31 Parked Regen Failed – DOC In Temp Preventing Dosing) Leaking Air System, Turbo Wastegate Fit Freightliner Detroit Diesel DD13 DD15 Turbocharger Actuator. USD$75.00 USD$140.00. Add to Cart. Recently Viewed. Turbo Fit Freightliner Detroit Diesel DD15 Turbocharger. USD$499.00 . WARNING： This product contains chemicals known to the state of California to cause cancer and birth defects or reproductive harm. …, Refer to section "Installation of the GHG14 DD15 Asymmetrical Turbocharger Exhaust Gas Recirculation Valve Actuator Pull Rod". 9. Install the turbocharger gasket, and the turbocharger. Refer to section "Installation of the GHG14 DD15 Asymmetrical Turbocharger". 10. Install the EGR/Hot Pipe and turbocharger heat shields. …, Proper troubleshooting of turbo components is an area that cannot be talked about enough. When dealing with Turbo and Actuator failures you are looking at several thousand dollars for the cost to repair. Replacing an actuator is much cheaper than buying a turbo meaning it is very important to separate the 2 components to determine failure., Disconnect the 120-pin Motor Control Module (MCM) connector and check for corroded, bent or broken pins. Ensure both the MCM and harness connector pins are checked. Repair or replace if needed. Turn ignition ON (key ON, engine OFF). Measure the voltage at pin 2 of the quantity control valve harness connector. If the voltage is 0, replace the MCM., Command the PWM 10 to 70%; wastegate actuator rod should begin to move.[c] Command the PWM 10 to 90%; wastegate actuator rod should be fully open. Go to next step. [d] If the actuator fails to move, verify air supply pressure equals truck air pressure. If pressure is OK, replace the VPOD. 16. Check the brakegate actuator., 305-13.pdf - Removal and Installation of the GHG14 DD15 Asymmetrical Turbocharger Flanged Exhausted Manifold Subject: Removal and Installation of the GHG14 DD15 Asymmetrical Turbocharger Flanged Exhausted Manifold Keywords: GHG14, DD15, HC, OEM, Created Date: 3/21/2013 9:23:12 AM, Turbo Wastegate Fit Freightliner Detroit Diesel DD13 DD15 Turbocharger Actuator. USD$75.00 USD$140.00. Add to Cart. Recently Viewed. Turbo Fit Freightliner Detroit Diesel DD15 Turbocharger. USD$499.00 . WARNING： This product contains chemicals known to the state of California to cause cancer and birth defects or reproductive harm. …, item 2 For Detroit Turbo Wastegate Actuator DD13 DD15 Turbo Freightliner For Detroit Turbo Wastegate Actuator DD13 DD15 Turbo Freightliner. AU $81.74 +AU $235.71 postage. You may also like. Current slide {CURRENT_SLIDE} of {TOTAL_SLIDES}- You may also like. Car & Truck EGR Valves., Turbo Wastegate Fit Freightliner Detroit Diesel DD13 DD15 Turbocharger Actuator. USD$75.00 USD$140.00. Add to Cart. Turbocharger For Detroit Diesel DD15 14.8L B3G A4720901480 Turbo. USD$750.00 USD$950.00. Add to Cart. Tags: Cartridge. Popular Items. For Caterpillar 3406E 3406 Turbocharger C15 Turbo Bigger HP (Bigger A/R) ..., Some units equipped with a Gen 5 DD15 engine (ESN 472912S) have experienced exhaust valve bridges falling out of place and in some cases, repeat failures. This is due to exhaust rocker arm adjusting screw wear as a result of insufficient lube during extended idle periods. It is recommended to reduce idle time whenever possible., DD5™ DD8™ DD13® DD15® DD16® Legacy Engines Detroit Engines Detroit Engines Mean Powerful Business. Detroit ® engines perform at their peak for miles and miles, with best-in-class fuel economy and low-cost maintenance and service. Every step of our design, testing and manufacturing process builds quality into every engine that bears the Detroit …, This can lead to overheating and potential engine damage. 3. Decreased fuel economy. A faulty EGR cooler can cause the engine to run less efficiently, resulting in decreased fuel economy. 4. Increased exhaust smoke. A failing EGR cooler can cause an increase in exhaust smoke, particularly white or blue smoke. 5., Noted below are a few of the common warning signs of a bad or failing throttle controller. 1. Intermittent throttle control. The throttle controller is controlled electrically as opposed to the older, mechanical cables that ran from the throttle pedal to the throttle body. In some instances, the electric signal is disrupted, whether due to a ..., CASTING #: 3772934. ACTUATOR: NA. VIN #: 3HSCTAPR39N122152. OEM #: 4720962099. USED DETROIT DD15 TURBOCHARGER TAG #2131420. Create Estimate. Part Info. (877)557-8782 Request Info Enterprise LKQ Acme Truck Parts Stockton CA. $1,200.00 ADD TO CART. , Detroit. Engine Model. DD15. DD15 (472903) Turbocharger, A4720961699, Holset HX55, All Turbos sold with a 30 day “parts... 1-877-781-7766. Email Seller., 0:00 / 11:11 Freightliner Cascadia DD13 DD15 DD16 no power turbo control problem spn 641 fmi 5 no turbo pressure Francisco Amaya 88.1K subscribers Subscribe 42K views 2 years ago..., The U010C still pops up after a few key cycles. Of course the dealer wants $6500 for a turbo/actuator replacement. The turbo was not locked up, and the sector gear moved freely when i replaced the actuator. City Diesel has been as helpful as they can be over the phone and email., 3 Installation of the GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator On the DD15 with an asymmetrical turbocharger, the Exhaust Gas Recirculation (EGR) actuator is located on the cylinder block as opposed to the turbo-compound model DD15, where the EGR actuator is mounted in a bracket on the exhaust manifold. Install as follows:, Have someone turn on key with some air in system and watch turbo actuator, it should cycle up and then down. throw some soapy water on actuator with engine running at high idle (1000 RPM or better)..sounds like actuator is leaking...also check wires at plug to VPOD that controls turbo. ... Freightliner Cascadia DD15 2018... emilko posted Oct 16 ..., problem, or a problem with symptoms but no diagnostic codes. Use this and the response as a guideline. Refer to Questionnaire Response Guidelinefound on page 1–6. 1. How often does the problem occur? Can you and the driver take the vehicle and demonstrate the problem in less than 30 minutes? 2. Has the vehicle been to other shops for the same ..., Use a EGR or Carburetor Cleaner to spray the valve and hoses. Reconnect the battery. STEP 4: EGR Valves are made up of various hoses along with the valve. You will want to spray all it it thoroughly and …, A “sloppy” or rough idle can be caused by one of several things. One of the reasons that your truck may have a rough idle is due to a defective EGR valve that is stuck in the open or closed position. 2. Excessive Smoke. Modern diesel engines produce next to no smoke. Coal rolling, locomotive-like engines are now a thing of the past., Turbo Wastegate Fit Freightliner Detroit Diesel DD13 DD15 Turbocharger Actuator. USD$75.00 USD$140.00. Add to Cart. Recently Viewed. Turbo Fit Freightliner Detroit Diesel DD15 Turbocharger. USD$499.00 . WARNING： This product contains chemicals known to the state of California to cause cancer and birth defects or reproductive harm. …